Flat Roof Replacement in Lincoln Park

01 Lincoln Park

Fix the fall, then lay the membrane.

Re-covering a flat roof without correcting the fall reproduces the failure on a new membrane. If water stood on the old system it will stand on the new one, in the same places, and the seams under it will be tested continuously rather than occasionally.

Lincoln Park

Flat Roof Replacement, and what it actually involves

On a low-slope roof the specification argument is usually about the membrane, and the thing that decides the outcome is usually the drainage.

Stripped to the deck, not re-covered over the old roof
Deck inspected once exposed, with a stated allowance
Scoped against the NJ Uniform Construction Code
Newark and the surrounding Essex, Hudson and Union towns

(973) 788-8324

Two workers on a low-slope roof behind a parapet — Replacement work

01 Low-slope systems

Replace the fall, not just the membrane

A flat roof that ponded before will pond again under a new membrane, in the same places, unless something about the drainage changes.

Ponding is a design fault, not weather

Water still standing forty-eight hours after rain means the fall, the drains or the deck have moved. A new membrane laid over that is being tested continuously instead of occasionally.

Drains sized and sited first

A blocked or undersized outlet turns the roof into a shallow tank. Replacement is the only realistic opportunity to correct outlet positions, so it should be taken.

Tapered insulation earns its cost

Where the structural deck cannot be re-pitched, tapered insulation builds the fall into the build-up. It is the difference between a roof that drains and one that merely has a membrane.

Every penetration is its own detail

Pipes, vents, mechanical curbs and fixings each get flashed individually. On a large roof these outnumber every other failure point put together.

Wet insulation does not dry

Saturated boards under an old membrane stay saturated once a new one is over them. If the survey shows wet insulation it comes out, or the new roof is compromised on day one.

Terminations and upstands

The membrane turning up a wall, and the bar that holds it there, take the stress. The field of the membrane rarely fails first.

02 Applied to Lincoln Park

What changes about this job here

Mixed stock means mixed systems, often on one site — an old built-up roof beside a newer single-ply. They fail differently and they cannot be replaced to one specification.

Lincoln Park — mixed era and mixed type

One of Newark's oldest built-up areas: nineteenth-century townhouses and civic buildings around the park, a good deal of it historically significant.

Reference point: the historic square at the southern end of Broad Street.

03 On the ground in Lincoln Park

What gets replaced here, and what makes it awkward

Where the difficulty sits

Roofs of this age have usually been re-covered more than once, and under the current covering there may be two earlier ones. New Jersey allows no more than two layers on a structure, so a third application means a full tear-off whatever the budget said.

Worth knowing locally

On a building this old the deck itself is the unknown. It cannot be assessed properly until the coverings are off, which is why an honest quote carries a stated allowance for deck repair.

An old roof covering being stripped back to the deck — Lincoln Park

Buildings in Lincoln Park

What the roofs are like in Lincoln Park

One of Newark's oldest built-up areas: nineteenth-century townhouses and civic buildings around the park, a good deal of it historically significant.

All areas covered

05 Local conditions

What this climate does to a new roof

Newark sits in a humid subtropical shading into humid continental (Koppen Cfa/Dfa) zone with a full freeze-thaw winter — the combination hardest on flashings, fixings and mortar.

Freeze-thaw finds every gap

Water that gets into a lap, a joint or a hairline crack and then freezes expands. Northern New Jersey cycles through that repeatedly each winter, so small defects do not stay small.

Meltwater behaves unlike rain

Melt moves slowly under a snow layer and refreezes at the cold eave, backing water up under the covering where pitch does not help. That is what the ice barrier exists for.

Driven rain arrives at an angle

Rain coming in sideways gets under laps that shed vertical rain perfectly well, which is why edge and flashing detail matters more than the covering specification.

Nearby & related

Flat Roof work close to Lincoln Park

The same job in the areas next door, and the other work we take on in this one.

Flat Roof Downtown Flat Roof Ironbound Flat Roof University Heights Flat Roof Roseville

Replacement in Lincoln Park Installation in Lincoln Park Shingle in Lincoln Park Storm Damage in Lincoln Park Multi-Family in Lincoln Park

See every area we do flat roof replacement in across Newark →

Questions

Common questions

General guidance about how these buildings are re-roofed, not a survey of any particular property.

Can the flat roof just be re-covered?

Only if the water drains. A membrane laid over a fall that already ponds will pond in the same places, and the seams under standing water are tested continuously rather than occasionally. Correcting the fall is usually the actual job.

Why does the quote vary so much between similar-looking buildings?

Because the era does. On mixed streets two addresses a block apart can have different deck construction, different layer counts and different ventilation, and those decide the price far more than the roof area does.

Will this need a permit?

Replacing more than a quarter of a roof surface within any twelve months requires a construction permit under the New Jersey Uniform Construction Code. A full replacement is over that threshold, so yes — and the work is inspected at stages.